Molecular behaviour of methanol and dimethyl ether in H-ZSM-5 catalysts as a function of Si/Al ratio: a quasielastic neutron scattering study
Journal article, 2020

The dynamical behaviour of methanol and dimethyl ether in H-ZSM-5 catalysts of differing Si/Al ratios (36 and 135) was probed using quasielastic neutron scattering to understand the effect of catalyst composition (Brønsted acid site concentration) on the behaviour of species present during the initial stages of the H-ZSM-5 catalysed methanol-to-hydrocarbons process. At room temperature in H-ZSM-5(36) isotropic methanol rotation was observed (rotational diffusional coefficient, DR = 2.6 × 1010 s-1), which contrasted qualitatively with H-ZSM-5(135) in which diffusion confined to a sphere matching the 5.5 Å channel width was observed, suggesting motion is more constrained in the lower Si/Al catalyst. At higher temperatures, confined methanol diffusion is exhibited in both catalysts with self-diffusion coefficients (Ds) measured in the range of 8-9 × 10-10 m2 s-1. However, the population of molecules immobile over the timescale probed by the instrument is significantly larger in H-ZSM-5(36), consistent with the far higher number of Brønsted acid adsorption sites. For dimethyl ether, diffusion confined to a sphere at all temperatures is observed in both catalysts with Ds measured in the range of 9-11 × 10-10 m2 s-1 and a slightly smaller fraction of immobile molecules in H-ZSM-5(135). The larger Ds values obtained for dimethyl ether arise from the sphere of confinement being larger in H-ZSM-5(36) (6.2 Å in diameter) than the 5.5 Å width of the pore channels. This larger width suggests that mobile DME is sited in the channel intersections, in contrast to the mobile methanol which is sited in the channels. An even larger confining sphere of diffusion was derived in H-ZSM-5(135) (∼8 Å in diameter), which we attribute to a lack of Brønsted sites, allowing for a larger free volume for DME diffusion in the channel intersections.


Oluwatoyin Omojola

University of Bath

Fritz Haber Institute of the Max Planck Society

Ian Silverwood

ISIS Neutron and Muon Source

Alexander O'Malley

STFC Rutherford Appleton Laboratory

Centre for Sustainable and Circular Technologies, Department of Chemistry, University of Bath, Claverton Down

Catalysis Science and Technology

2044-4753 (ISSN) 2044-4761 (eISSN)

Vol. 10 13 4305-4320

Subject Categories

Physical Chemistry

Chemical Engineering



More information

Latest update

2/8/2022 1