Ilmenite and Nickel as Catalysts for Upgrading of Raw Gas Derived from Biomass Gasification
Artikel i vetenskaplig tidskrift, 2013

Two metal oxides, naturally occurring ilmenite (iron titanium oxide) and manufactured nickel oxide supported on an α-Al2O3 matrix (NiO/AL2O3), were compared as catalysts for secondary biomass gas upgrading. The experiments were conducted in a Chemical-Looping Reforming (CLR) reactor, which combines biomass gas upgrading with continuous regeneration of coke deposits. The CLR system was fed with a tar-rich producer gas from the Chalmers 2–4 MW biomass gasifier, and the possibilities to reduce the tar fraction and to increase the yield of hydrogen were evaluated for temperatures between 700°C and 880°C. A system-wide molar balance was established, to enable calculations of tar removal efficiency on a mass basis; these results were further compared with those for the more widely used tar-to-reformed gas ratio, yielding tar concentrations in units of gtar/Nm3gas. Both materials exhibited activity with respect to tar decomposition and increased the yield of hydrogen. In addition, both tar removal and hydrogen production were increased with increases in temperature. All the phenolic compounds and a large proportion of the one-ring branched tars were decomposed at 800ºC by the two catalysts, despite the fact that the tar load in the raw gas was as high as 30 gtar/Nm3gas. Results from the mole balance showed that it is important to specify on what basis the tar removal efficiency is calculated. The tar removal efficiency was calculated to 95% for the Ni/Al2O3 catalyst at 880°C and to 60% for the ilmenite catalyst at 850°C on tar-to-reformed gas basis. When the produced permanent gases were removed from the reformed gas the same calculations yielded the tar removal efficiency of 86% and 42% respectively. The testing of serial samples of the effluent stream from the regeneration reactor for carbon oxides showed that coke was removed from the catalyst, and no deactivation by coke deposits was detected during the 8 hours of operation of the CLR reactor.


Fredrik Lind

Chalmers, Energi och miljö, Energiteknik

Nicolas Berguerand

Chalmers, Energi och miljö, Energiteknik

Martin Seemann

Chalmers, Energi och miljö, Energiteknik

Henrik Thunman

Chalmers, Energi och miljö, Energiteknik

Energy & Fuels

0887-0624 (ISSN) 1520-5029 (eISSN)

Vol. 27 2 997-1007


Hållbar utveckling




Kemiska processer

Annan kemiteknik



Mer information